Unknown Pipeline

All POL/SITREP's for this site Unknown Pipeline
Lodi, OH - EPA Region V
POLREP #1
Initial/Final
Printer Friendly  |   PDF
 
U.S. ENVIRONMENTAL PROTECTION AGENCY
POLLUTION/SITUATION REPORT
Unknown Pipeline - Removal Polrep
Initial and Final Removal Polrep

EPA Emergency Response

UNITED STATES ENVIRONMENTAL PROTECTION AGENCY
Region V

Subject: POLREP #1
Initial/Final
Unknown Pipeline
Z5QE
Lodi, OH
Latitude: 41.0436430 Longitude: -82.0034170


To:
From: Stephen Wolfe, On-Scene Coordinator
Date: 10/25/2016
Reporting Period: 09/23/16 through 10/25/16

1. Introduction
  1.1 Background
   
Site Number: Z5QE    Contract Number:  
D.O. Number:      Action Memo Date:  
Response Authority: OPA    Response Type: Emergency
Response Lead: EPA    Incident Category: Removal Action
NPL Status: Non NPL    Operable Unit:
Mobilization Date: 9/23/2016    Start Date: 9/23/2016
Demob Date: 10/25/2016    Completion Date: 10/25/2016
CERCLIS ID:    RCRIS ID:
ERNS No.:    State Notification: yes
FPN#: E16503    Reimbursable Account #:

1.1.1 Incident Category

Abandoned oil pipeline (leaking)

1.1.2 Site Description


1.1.2.1 Location

 
The Unknown Pipeline Site is located at a residential property in Lodi, Medina County, Ohio (GPS Coordinates 41.045157 degrees north and 82.005163 degrees west).   The pipeline crosses a residential property and intersects a creek that runs across the front of the property, parallel to the road.   The creek is a tributary to the Black River.  The pipeline transects approximately 600 feet of the residential property.

The pipeline was installed in the early 1900s and went through several different ownerships.   The pipeline was used to transport petroleum products from Lodi, Ohio to Killbuck, Ohio (approximately 40 miles).  The pipeline was last sold in the 1990s to a company for scrapping purposes; however, the purchasing company did not remove the pipeline.   The site of the release was is an open field on a residential property (horse farm).   According to the property owner, there is no information in the property deeds that indicate that a pipeline crosses the property.

 
1.1.2.2 Description of Threat

In June 2015, Ohio EPA responded to a release of oil to a creek.   The source was discovered to be a six-inch pipeline that crossed a small creek in the front of a residential yard.  Ohio EPA placed a clamp on the leak, removed free oil from the creek, and excavated contaminated soil for disposal.   The site was referred to EPA as the clamp was a temporary fix.   In July 2016 a second leak occurred at the same location and Ohio EPA responded and controlled the situation with another clamp.   Available records indicated the pipeline was abandoned in the 1990s.  Since efforts to locate the current owners of the pipeline were unsuccessful, and two leaks occurred at the same location,  EPA began planning for an emergency removal action.

1.1.3 Preliminary Removal Assessment/Removal Site Inspection Results

Ohio EPA controlled two leaks in the pipeline with clamps and remediated contaminated soil (June 2015 and July 2016).   A four-inch line was discovered running parallel to the six-inch line and was partly above ground in a deteriorated state.  Both lines crossed a small creek (the four-inch line was completely under water) and both leaks occurred in the six-inch line at the crossing point.       

2. Current Activities
  2.1 Operations Section
   

2.1.1 Narrative

2.1.2 Response Actions to Date

On August 24, 2016, ERRS and their pipeline subcontractor were on site to inspect the six-inch pipe and its suitability for "hot tapping" (drilling a hole through an installed valve).  The pipeline subcontractor also inspected the four-inch pipeline where visible and concluded that the line was too deteriorated to attempt any work at this time.

On September 23, 2016, ERRS and their subcontractor arrived on site to "hot tap" the six inch pipeline.  Two locations of the pipe were tapped, one location for draining purposes and one location as a vent.  The four-inch pipeline was uncovered in several different locations and the pipeline subcontractor agreed to perform a hot tap on the smaller pipeline at a later date as the line appeared solid in the uncovered locations.  After the taps were installed on the six-inch pipeline, oil samples were collected for disposal analysis.

On October 11, 2016, ERRS returned to the site to begin removing oil from the pipelines.  The four-inch pipeline was excavated to prepare the line for hot tapping later in the week.  Oil was drained from the six-inch pipeline using a vacuum truck.  

On October 12, 2016, ERRS returned to the site to finish emptying the six-inch line.  After no material was visible in the vent tap, the vacuum was removed from the line and the six-inch line was cut at an up-gradient location for capping and removal.   The six-inch line was permanently capped (leading up-gradient from the property).  

On October 13, 2016, a subcontractor for ERRS returned to the site to install hot taps on the 4-inch line.  After the hot taps were installed, ERRS removed material from the pipeline using a vacuum truck.  Once material no longer emptied from the 4-inch line, the vacuum was turned off and the 4-inch pipeline was cut and capped on the up-gradient portion of the pipe. 

On October 14, 2016, leaks were observed on the 4-inch line near the down gradient tap location.  Water was coming out of several holes that were not observed the day before.  It was assumed that the water was infiltrating the pipeline from the creek; therefore, the 4-inch line was cut past the location where it crossed the creek and capped.  All water leaking from the pipe was removed with the vacuum truck due to oil contamination, and the pipe was emptied again.  The portion of the 4-inch pipeline was removed that crossed the creek and numerous holes were visible in the pipe.  Before departing for the evening, additional holes were observed in the 4 inch pipeline down-gradient from the creek and the decision was made to remove additional lengths of pipe to ensure water did not infiltrate the pipe, become contaminated with residual oil, and leak from the pipe. 

Five totes (1,650 gallons) of petroleum material were transported from the site for disposal at EQ Detroit, located in Detroit, Michigan.

On October 15, 2016, ERRS removed approximately 150 feet of the 4-inch pipeline (south of the bridge that crosses the creek) and permanently capped both ends of the pipeline that was left in place.   

on October 17, 2016, ERRS removed the tap from the 6-inch line in the south field.  Plugs were placed in the line and the line was clamped to seal the "tap" hole.  The 6-inch line could not be cut in this location as the pipeline was located very close to the ground surface and any plugs installed on the end would stick above the ground surface and endanger the horses that use the field.    

From October 17 through October 19, 2016, ERRS cut approximately 200 feet of the 6-inch pipeline and 4-inch pipeline into 8 foot sections.  The inside of the pipe sections were cleaned by pushing sorbent pads through and collecting any material in a drum.  The excavated areas were backfilled and graded for restoration.  On October 18, 2016, 3 totes (990 gallons) of petroleum material and 2 drums of pads were taken to EQ Detroit, located in Detroit Michigan for disposal. 

On October 19, 2016, 2 drums of sorbent pads and boom were taken to EQ Detroit, located in Detroit Michigan for disposal.   

On October 24, 2016 the roll-off box containing the pipe and miscellaneous debris was removed from site and taken to American Landfill, Waynesburg, Ohio for disposal.  An ERRS subcontractor was on-site to perform final restoration (grading/topsoil/seeding).

On October 25, 2016, final restoration was completed and ERRS demobilized from the site.

2.1.3 Enforcement Activities, Identity of Potentially Responsible Parties (PRPs)

The current owners of the pipelines has been identified; however, efforts to locate them have been unsuccessful.  Information requests as well as Notices of Federal Interest/Assumption were mailed to available addresses and all were returned unopened. 

A Previous owner of the pipeline provided information to the EPA that indicated portions of the pipeline was removed in the 1990s approximately 1 mile away from the leak location.

2.1.4.1 Regional Metrics

Regional Metrics
This is an Integrated River Assessment. The numbers should overlap. Miles of river systems cleaned and/or restored NA
Cubic yards of contaminated sediments removed and/or capped NA
Gallons of oil/water recovered 2,640
Acres of soil/sediment cleaned up in floodplains and riverbanks NA
Stand Alone Assessment Number of contaminated residential yards cleaned up NA
Number of workers on site 4
Contaminant(s) of Concern Petroleum
Oil Response Tracking
Estimated volume Initial amount released unknown
Final amount collected 2,640 gallons
CANAPS Info FPN Ceiling Amount $185,000
FPN Number E16503
Body of Water affected Black River
Administrative and Logistical Factors (Place X where applicable)
  Precedent-Setting HQ Consultations (e.g., fracking, asbestos)   Community challenges or high involvement   Radiological
  More than one PRP   Endangered Species Act / Essential Fish Habitat issues   Explosives
  AOC   Historic preservation issues X Residential impacts
  UAO   NPL site   Relocation
  DOJ involved   Remote location   Drinking water impacted
  Criminal Charges Have Been Filed*   Extreme weather or abnormal field season   Environmental justice
  Tribal consultation or coordination or other issues   Congressional involvement   High media interest
  Statutory Exemption for $2 Million   Statutory Exemption for 1 Year   Active fire present
  Hazmat Entry Conducted – Level A, B or C   Incident or Unified Command established   Actual air release (not threatened)
Green Metrics
Metric Amount Units
Diesel Fuel Used NA gallons
Unleaded Fuel Used NA gallons
Alternative/E-85 Fuel Used NA gallons
Electricity from electric company   NA kWh
Electric Company Name and Account # NA  
Electricity from sources other than the electric company NA kWh
Solid waste reused NA  
Solid waste recycled NA  
Water Used   NA gallons

2.1.4.2 Progress Metrics

Waste Stream Medium Quantity Manifest # Treatment Disposal
 Petroleum material  liquid  2,640 gallons 014109727JJK
014109714JJK
   EQ Detroit, Detroit, Michigan
 Pipe/debris  solid  500 feet  353689   American Landfill, Waynesburg, Ohio
 miscellaneous pads/boom  solid  4 drums 014109714JJK
014109728JJK
   EQ Detroit, Detroit, Michigan


  2.2 Planning Section
   

2.2.1 Anticipated Activities

 None- Response Complete

2.2.1.1 Planned Response Activities
None- Response Complete

2.2.1.2 Next Steps
None- Response Complete

2.2.2 Issues

ERRS planned to use pressurized nitrogen to force material through the pipe for cleaning (known as 'pigging") however the equipment malfunctioned and the removed pipe had to be cleaned out manually.

Additional holes in the 4-inch pipeline were discovered resulting in additional contaminated water that had to be disposed of and an additional ~150 feet of pipe that had to be removed that was unanticipated

 

  2.3 Logistics Section
    ERRS coordinated logistics for the site

  2.4 Finance Section
    No information available at this time.

  2.5 Other Command Staff
   

2.5.1 Safety Officer
The OSC and ERRS RM is fulfilling this Role.

daily safety meetings were held prior to the start of each days work and additional briefings were held as necessary when hazardous work was conducted (pipe cutting, pigging (pressurized gas) etc.

2.5.2 Liaison Officer
NA
2.5.3 Information Officer

NA

3. Participating Entities
 

3.1 Unified Command
NA
3.2 Cooperating Agencies

Ohio EPA originally responded to the leaking pipeline (June 2015 and July 2016).  EPA completed the response actions and kept the Ohio EPA informed of actions. 



4. Personnel On Site
 

EPA OSC (1)

ERRS (4)

subcontractors (2)

5. Definition of Terms
  No information available at this time.

6. Additional sources of information
  No information available at this time.

7. Situational Reference Materials
  No information available at this time.